Related Manuals for Husqvarna 65022ESX
Summary of Contents for Husqvarna 65022ESX
- Page 1 65022ESX Owner’s Manual / 961430039 / 2009-01 532 41 91-48 Rev. 3 01.12.09 TH/BY/BY/BY Printed in U.S.A.
-
Page 2: Safety Rules
SAFETY RULES Safe Operation Practices for Walk-Behind Mowers IMPORTANT: THIS CUTTING MACHINE IS CAPABLE OF AMPUTATING HANDS AND FEET AND THROW ING OBJECTS. FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS COULD RESULT IN SERIOUS INJURY OR DEATH. • Stop the blade(s) when crossing gravel drives, walks, Look for this symbol to point out im- or roads. -
Page 3: Table Of Contents
• Never refuel the machine indoors. • Keep nuts and bolts, especially blade attachement bolts, tight and keep equipment in good condition. • Never store the machine or fuel container where there is an open flame, spark or pilot light such as a water •... -
Page 4: Assembly
ASSEMBLY Read these instructions and this man u al in its entirety before you attempt to assemble or operate your new lawn mow er. IMPORTANT: THIS LAWN MOWER IS SHIPPED WITH OUT OIL OR GASOLINE IN THE ENGINE. Your new lawn mower has been as sem bled at the factory with the ex cep tion of those parts left unassembled for shipping purposes. -
Page 5: Operation
OPERATION KNOW YOUR LAWN MOWER READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR LAWN MOWER. Compare the illustrations with your lawn mower to familiarize yourself with the location of various controls and adjust- ments. Save this manual for future reference. These symbols may appear on your lawn mower or in literature supplied with the product. -
Page 6: To Convert Mower
OPERATION The operation of any lawn mower can result in foreign objects thrown into the eyes, which can result in severe eye damage. Always wear safety glasses or eye shields while operating your lawn mower or performing any adjustments or repairs. We recommend standard safety glasses or a wide vision safety mask over spectacles. -
Page 7: Before Starting Engine
OPERATION SIDE DIS CHARG ING (See Fig. 7) CAUTION: Do not run your lawn mower • Mulcher plug must be installed into rear discharge with out mulcher plug or ap proved grass open ing of mower. catch er in place. Never at tempt to op- er ate the lawn mow er with the rear door •... -
Page 8: Stop/Start Engine
OPERATION MOWING TIPS GASOLINE ENGINE FILLER OIL CAP CAUTION: Do not use de-thatcher blade attachments on your mower. Such at- tachments are hazardous, will damage your mower and could void your warranty. • Under certain conditions, such as very tall grass, it may be necessary to raise the height of cut to reduce pushing effort and to keep from overloading the engine and leaving clumps of grass clippings. -
Page 9: Maintenance Schedule
MAINTENANCE BEFORE AFTER EVERY EVERY EVERY BEFORE EACH EACH 25 HOURS STORAGE HOURS OR SEASON HOURS Check for Loose Fasteners Clean / Inspect Grass Catcher * Check Tires Check Drive Wheels *** Clean Lawn Mower **** Clean under Drive Cover *** Check Drive Belt / Pulleys *** Check / Sharpen / Replace Blade Lubrication... -
Page 10: Drive Wheels
MAINTENANCE LAWN MOWER 3. Be sure the trailing edge of blade (opposite sharp edge) is up toward the engine. Always observe safety rules when performing main te nance. 4. Install the blade bolt with the lock washer and hard ened washer into blade adapter and crank shaft. -
Page 11: Muffler/Spark Plug
MAINTENANCE ENGINE TO CLEAN AIR FILTER 1. Loosen screw and tilt cover to re move. LUBRICATION 2. Carefully remove cartridge. Use only high quality detergent oil rated with API service 3. Clean by gently tapping on a flat surface. If very dirty, classification SG–SL. -
Page 12: Service And Adjustments
SERVICE AND ADJUSTMENTS CAUTION: TO AVOID SERIOUS INJURY, BEFORE PERFORMING ANY SERVICE OR ADJUSTMENTS: 1. Release control bar and stop engine. 2. Make sure the blade and all moving parts have completely stopped. 3. Disconnect spark plug wire from spark plug and place where it cannot come in contact with plug. LAWN MOWER ENGINE PULLEY TO ADJUST CUTTING HEIGHT... -
Page 13: Storage
SERVICE AND ADJUSTMENTS ENGINE ENGINE SPEED MOWING MOWING POSITION POSITION Your engine speed has been factory set. Do not attempt to increase engine speed or it may result in personal injury. If you believe that the engine is running too fast or too slow, take your lawn mower to an authorized service center for repair and adjustment. -
Page 14: Fuel System
STORAGE HANDLE (See Figs. 18 and 19) ENGINE FUEL SYSTEM You can fold your lawn mower handle for storage. 1. Squeeze the bottom ends of the lower handle toward IMPORTANT: IT IS IMPORTANT TO PREVENT GUM DEPOSITS each other until the lower handle clears the handle FROM FORMING IN ESSENTIAL FUEL SYSTEM PARTS SUCH AS CARBURETOR, FUEL FILTER, FUEL HOSE, OR TANK DURING bracket, then move handle forward. -
Page 15: Trou Ble Shoot Ing
TROUBLESHOOTING POINTS PROBLEM CAUSE CORRECTION Does not start 1. Dirty air filter. 1. Clean/replace air filter. 2. Out of fuel. 2. Fill fuel tank. 3. Stale fuel. 3. Empty fuel tank and refill tank with fresh, clean gasoline. 4. Water in fuel. 4. -
Page 16: Repair Parts
ROTARY LAWN MOWER - - MODEL NUMBER 65022ESX (96143003900) - PRODUCT NUMBER 961 43 00-39... - Page 17 ROTARY LAWN MOWER - - MODEL NUMBER 65022ESX (96143003900) - PRODUCT NUMBER 961 43 00-39 PART PART DESCRIPTION DESCRIPTION 532 19 99-83 Upper Handle (Includes Foam Grip) 532 41 91-92 Handle Bracket Assembly, RH 532 40 19-94 Cable, Operator Presence...
- Page 18 ROTARY LAWN MOWER - - MODEL NUMBER 65022ESX (96143003900) - PRODUCT NUMBER 961 43 00-39...
- Page 19 ROTARY LAWN MOWER - - MODEL NUMBER 65022ESX (96143003900) - PRODUCT NUMBER 961 43 00-39 PART PART DESCRIPTION DESCRIPTION 532 19 46-53 Drive Control Cable 532 17 55-51 Screw, Shoulder, Hex Head #10-28 x 5/8 532 15 04-95 Retainer, Spring...
-
Page 20: Warranty
Rental Warranty: 90 days on all applicable professional equipment reference warranty time period charts mailed to Husqvarna Forest & Garden Company. This card should be mailed within ten (10) days from the date of purchase located in the back of the Retailer Warranty Policy & Procedure Manual.