Sony CDX-F5500 Service Manual
Hide thumbs
Also See for CDX-F5500:
- Operating instructions manual (84 pages) ,
- Service manual (52 pages) ,
- Installation/connections (4 pages)
Table of Contents
Advertisement
Quick Links
CDX-F5500/F5500X
SERVICE MANUAL
Ver 1.0 2003. 12
• The tuner and CD sections have no adjustments.
AUDIO POWER SPECIFICATIONS
POWER OUTPUT AND TOTAL HARMONIC DISTORTION
23.2 watts per channel minimum continuous average power into
4 ohms, 4 channels driven from 20 Hz to 20 kHz with no more
than 5% total harmonic distortion.
CD player section
Signal-to-noise ratio
120 dB
Frequency response
10 – 20,000 Hz
Wow and flutter
Below measurable limit
Tuner section
FM
Tuning range
US, Canadian Model:
87.5 – 107.9 MHz
E model:
FM tuning interval:
50 kHz/200 kHz switchable
87.5 – 108 MHz (at 50 kHz step)
87.5 – 107.9 MHz (at 200 kHz step)
Antenna terminal
External antenna connector
Intermediate frequency 10.7 MHz/450 kHz
Usable sensitivity
9 dBf
Selectivity
75 dB at 400 kHz
Signal-to-noise ratio
67 dB (stereo),
69 dB (mono)
Harmonic distortion at 1 kHz
0.5% (stereo),
0.3% (mono)
Separation
35 dB at 1 kHz
Frequency response
30 – 15,000 Hz
Sony Corporation
9-961-449-01
2003L04-1
e Vehicle Company
© 2003. 12
Published by Sony Engineering Corporation
Photo: CDX-F5500
Model Name Using Similar Mechanism
CD Drive Mechanism Type
Optical Pick-up Name
SPECIFICATIONS
AM
Tuning range
Antenna terminal
Intermediate frequency 10.7 MHz/450 kHz
Sensitivity
Power amplifier section
Outputs
Speaker impedance
Maximum power output 52 W × 4 (at 4 ohms)
General
Outputs
Inputs
FM/AM COMPACT DISC PLAYER
US Model
Canadian Model
E Model
CDX-3300/3300S
MG-611MA-186//K
KSS1000E
US, Canadian Model:
530 – 1,710 kHz
E Model:
AM tuning interval:
9 kHz/10 kHz switchable
531 – 1,602 kHz (at 9 kHz step)
530 – 1,710 kHz (at 10 kHz step)
External antenna connector
30 µV
Speaker outputs
(sure seal connectors)
4 – 8 ohms
Audio outputs terminal (front, rear/sub switchable)
Power antenna relay control terminal
Power amplifier control terminal
Telephone ATT control terminal
Remote controller input terminal
BUS control input terminal
BUS audio input terminal
Antenna input terminal
CDX-F5500
CDX-F5500X
1
Advertisement
Table of Contents
Related Manuals for Sony CDX-F5500
Summary of Contents for Sony CDX-F5500
- Page 1 35 dB at 1 kHz BUS control input terminal Frequency response 30 – 15,000 Hz BUS audio input terminal Antenna input terminal FM/AM COMPACT DISC PLAYER Sony Corporation 9-961-449-01 2003L04-1 e Vehicle Company © 2003. 12 Published by Sony Engineering Corporation...
- Page 2 Front panel case (1) Card remote commander RM-X115 Note optical pick-up This unit cannot be connected to a digital preamplifier or an equalizer which is Sony BUS system compatible. Design and specifications are subject to change without notice. SERVICE NOTES...
- Page 3 CDX-F5500/F5500X Notes on CD-Rs (recordable CDs)/CD-RWs (rewritable UNLEADED SOLDER CDs) Boards requiring use of unleaded solder are printed with the lead This unit can play the following discs: free mark (LF) indicating the solder contains no lead. (Caution: Some printed circuit boards may not come printed with the lead free mark due to their particular size.)
-
Page 4: Table Of Contents
CDX-F5500/F5500X TABLE OF CONTENTS 1. GENERAL Location of Controls (US, Canadian Model) ......5 Location of Controls (E Model) ..........5 Connections (US, Canadian Model) ........6 Connections (E Model) ............7 2. DISASSEMBLY 2-1. Sub Panel Assy (CD) ............9 2-2. -
Page 5: General
CDX-F5500/F5500X SECTION 1 GENERAL This section is extracted from instruction manual. (US, Canadian Model) (E Model) Location of controls Location of controls Refer to the pages listed for details. Refer to the pages listed for details. OPEN OPEN SEEK SEEK... -
Page 6: Connections (Us, Canadian Model)
CDX-F5500/F5500X Connections (US, Canadian Model) CDX-F5500 only CDX-F5500 uniquement Source selector (not supplied) Supplied with the CD/MD changer Sélecteur de source Fourni avec le changeur de CD/MD (non fourni) Supplied with XA-C30 XA-C30 Fourni avec le XA-C30 AUDIO OUT REMOTE... -
Page 7: Connections (E Model)
CDX-F5500/F5500X Connections (E Model) -
Page 8: Disassembly
CDX-F5500/F5500X SECTION 2 DISASSEMBLY Note : This set can be disassemble according to the following sequence. 2-1. SUB PANEL ASSY (CD) (Page 9) 2-2. CD MECHANISM BLOCK (Page 9) 2-10. SERVO BOARD 2-3. MAIN BOARD 2-4. CHASSIS (T) SUB ASSY... -
Page 9: Sub Panel Assy (Cd)
CDX-F5500/F5500X Note : Follow the disassembly procedure in the numerical order given. 2-1. SUB PANEL ASSY (CD) 3 two claws 2 two claws CNP802 1 two screws (+PTT 2.6 x 6) 5 sub panel assy (CD) 2-2. CD MECHANISM BLOCK... -
Page 10: Main Board
CDX-F5500/F5500X 2-3. MAIN BOARD 1 three screws (+BTT) 2 two screws (+PTT 2.6 x 8) 3 MAIN board 2-4. CHASSIS (T) SUB ASSY 4 claw 2 two screws (+P 1.7 x 2.2) 1 two screws (+P 1.7 x 2.2) 6 chassis (T) sub assy... -
Page 11: Roller Arm Assy
CDX-F5500/F5500X 2-5. ROLLER ARM ASSY 3 washer (1.1 – 2.5) 5 roller arm assy 4 worm wheel (RA) 2 spring (RAR) 1 spring (RAL) 2-6. CHASSIS (OP) ASSY qa chassis (OP) assy 0 compression spring (damper) lever (D) 4 washer... -
Page 12: Optical Pick-Up
CDX-F5500/F5500X 2-7. OPTICAL PICK-UP 2 chucking arm sub assy 5 claw 1 tension coil spring (CHKG) 7 optical pick-up 6 main shaft 4 rack (SL) 3 screw (+B 1.4 x 5) 2-8. SL MOTOR ASSY (M902) 1 screw (+P 1.4 x 1.8) -
Page 13: Le Motor Assy (M903)
CDX-F5500/F5500X 2-9. LE MOTOR ASSY (M903) 8 screw 0 woam (LEB) assy (+M 1.7 x 2.5) 9 bearing (LEB) 2 washer qa screw (+M 1.7 x 2.5) qf two toothed lock screws 3 gear (LE1) (+M 1.4 ) lever (D) -
Page 14: Diagrams
CDX-F5500/F5500X SECTION 3 DIAGRAMS 3-1. IC PIN DESCRIPTIONS • IC3 CXD3059AR (DIGITAL SERVO/DIGITAL SIGNAL PROCESSOR) (SERVO BOARD (1/2)) Pin No. Pin Name Pin Description MIRR Mirrer signal input/output DFCT Defect signal input/output Focus OK signal input/output — Ground pin LOCK Not used in this set. - Page 15 CDX-F5500/F5500X Pin No. Pin Name Pin Description CLTV VCO1 control voltage input FILO Filter signal output for master PLL FILI Filter signal input for master PLL Charge pomp output for master PLL AVDD5 — Analog power supply pin DDVROUT DC/DC converter output...
- Page 16 CDX-F5500/F5500X Pin No. Pin Name Pin Description XLAT Latch signal input CLOK Serial data transfer clock signal input — Digital power supply pin for internal SENS SENS signal output SCLK Clock signal input for SENS serial data read out ATSK...
- Page 17 CDX-F5500/F5500X • IC801 MB90487PF-G-103-BNDE1 (SYSTEM CONTROL) (MAIN BOARD (2/2)) Pin No. Pin Name Pin Description Audio mute control signal output 2 to 4 — Not used in this set. (Open) BEEP Beep signal output to power amp IC VOL ATT...
- Page 18 CDX-F5500/F5500X Pin No. Pin Name Pin Description TEL ATT TEL ATT signal output ACC IN Accessory power supply detect signal input SIRCS Remote control signal (infrared rays) input RAM BU Not used in this set. (Fixed at “L”.) TEST IN...
-
Page 19: Block Diagram -Cd Section
CDX-F5500/F5500X 3-2. BLOCK DIAGRAM — CD SECTION — • R-ch is omitted due to same as L-ch. • Siganal Path : CD PLAY DETECTOR MAIN RFACO 42 RFACI ASYO 45 ASYI AOUT1 CD-L SECTION (Page 20) AOUT2 R-CH RF AMP,DIGITAL SERVO,... -
Page 20: Block Diagram -Main Section
CDX-F5500/F5500X 3-3. BLOCK DIAGRAM — MAIN SECTION — ELECTRONIC VOLUME IC401 R-CH AUDIO IN R-CH CD-L 9 C2 SECTION OUTS1 (Page 19) R-CH 8 C1 REAR PJ401 OUTS2 R-CH AUDIO OUT R-CH FRONT AUDIO OUT TUX601 POWER AMP R-CH MUTE... -
Page 21: Block Diagram -Display Section
CDX-F5500/F5500X 3-4. BLOCK DIAGRAM — DISPLAY SECTION — 3-5. CIRCUIT BOARDS LOCATION SYSTEM CONTROL LCD DRIVER IC801 (3/3) IC901 SERVO board ROTARY SENSOR board LCD901 ENCODER SEG10 RE901(1/2) LIQUID LCD SO SEG66 CRYSTAL SPEAKER board LCD SCK DISPLAY COM1 PANEL... -
Page 22: Note For Printed Wiring Boards And Schematic Diagrams
CDX-F5500/F5500X 3-6. NOTE FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS 3-7. WAVEFORMS THIS NOTE IS COMMON FOR PRINTED WIRING — Servo Board — BOARDS AND SCHEMATIC DIAGRAMS. — Main Board — (MODE: CD PLAY) (In addition to this, the necessary note is printed in each block.) -
Page 23: Printed Wiring Boards -Cd Mechanism Section
CDX-F5500/F5500X 3-8. PRINTED WIRING BOARDS — CD MECHANISM SECTION — • Refer to page 21 for Circuit Boards Location. : Uses unleaded solder. R107 R139 R116 C110 R109 C109 R102 C115 R111 R144 R122 R128 R127 R143 R141 R119 R117... -
Page 24: Schematic Diagram -Cd Mechanism Section (1/2)
CDX-F5500/F5500X 3-9. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (1/2) — • Refer to page 22 for Waveforms. TP59 TP60 TP57 TP61 TP180 TP181 TP129 TP72 TP123 TP128 TP139 TP53 TP56 TP140 TP55 TP167 TP54 TP48 TP49 TP71 TP175 TP47 R114... -
Page 25: Schematic Diagram -Cd Mechanism Section (2/2)
CDX-F5500/F5500X • Refer to page 22 for Waveform. 3-10. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (2/2) — • Refer to page 32 for IC Block Diagrams. (Page 24) R136 R146 R117 TP70 IC B/D TP11 TP12 R140 TP19 TP20 TP17... -
Page 26: Schematic Diagram -Main Section (1/2)
CDX-F5500/F5500X 3-11. SCHEMATIC DIAGRAM — MAIN SECTION (1/2) — • Refer to page 32 for IC Block Diagram. TUX601 PJ601 C433 C434 C435 PJ401 C436 R426 C439 C609 C443 R430 C108 JR10 IC100 IC B/D C113 C424 R416 C440 R431... -
Page 27: Schematic Diagram -Main Section (2/2)
CDX-F5500/F5500X 3-12. SCHEMATIC DIAGRAM — MAIN SECTION (2/2) — • Refer to page 22 for Waveforms. (Page 26) C447 R447 C802 D702 IC803 C446 C809 R821 C801 R823 C441 C810 R822 R448 CN751 C709 D701 C707 R834 R832 L703 R708... -
Page 28: Printed Wiring Boards -Main Section
CDX-F5500/F5500X 3-13. PRINTED WIRING BOARDS — MAIN SECTION — • Refer to page 21 for Circuit Boards Location. : Uses unleaded solder. PJ401 PJ601 CNP900 CNJ900 CNP901 C436 C435 C433 C113 R427 R443 F901 JW111 R418 C990 C991 C443 IC100... -
Page 29: Printed Wiring Board -Relay Section
CDX-F5500/F5500X 3-14. PRINTED WIRING BOARD — RELAY SECTION — • Refer to page 21 for Circuit Boards Location. : Uses unleaded solder. (Page 30) LED931 CNP902 R931 LED930 S931 C973 (Page 28) 3-15. SCHEMATIC DIAGRAM — RELAY SECTION — CNP903... -
Page 30: Printed Wiring Board -Display Section
CDX-F5500/F5500X 3-16. PRINTED WIRING BOARD — DISPLAY SECTION — • Refer to page 21 for Circuit Boards Location. : Uses unleaded solder. S902 IC951 S904 LED909 LED902 LED907 LED905 LCD901 S905 LED927 LED924 S913 S917 S916 S915 S914 S912 S911... -
Page 31: Schematic Diagram -Display Section
CDX-F5500/F5500X 3-17. SCHEMATIC DIAGRAM — DISPLAY SECTION — (Page... -
Page 32: Ic Block Diagrams
CDX-F5500/F5500X 3-18. IC BLOCK DIAGRAMS IC1 LA6560-TE-L-E (SERVO Board) IC401 BD3808FS (MAIN Board) 36 S-GND THERMAL SHUTDOWN INPUT 35 VCONT VCC2 BTL-AMP MUTE 34 MUTE OUTPUT OUTPUT ON/OFF VLO- CONTROL FADER FADER FADER FADER 33 VIN4 (0~-58, (0~-58, (0~-58, (0~-58, C BUS -∞dB) -
Page 33: Exploded Views
CDX-F5500/F5500X SECTION 4 EXPLODED VIEWS NOTE: • The mechanical parts with no reference • Color Indication of Appearance Parts The components identified by mark 0 or dotted line with mark number in the exploded views are not supplied. Example : 0 are critical for safety. -
Page 34: Front Panel Section
X-3384-284-1 PANEL ASSY (SVX), FRONT BACK X-3384-288-1 BUTTON KIT (SVX) ASSY (F5500X) X-3378-390-3 CASE (PANEL) ASSY (for FRONT PANEL) X-3384-637-1 KNOB VOL (SVX) ASSY A-3220-965-A FP-CDX-F5500//C (U) (F5500) X-3384-286-1 PANEL ASSY (SVX), FRONT (F5500) A-3220-966-A FP-CDX-F5500X//C (E) (F5500X) X-3384-287-1 PANEL ASSY (SVX), FRONT (F5500X) -
Page 35: Cd Mechanism Section (1)
CDX-F5500/F5500X 4-3. CD MECHANISM SECTION (1) (MG-611MA-186//K) not supplied not supplied (SENSOR board) not supplied not supplied Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark A-3372-455-A CHASSIS (T) SUB ASSY 3-253-748-01 DAMPER (S) 3-253-729-01 SPRING (LTR), TENSION COIL 3-352-758-31 SCREW (M1.7), TOOTHED LOCK... -
Page 36: Cd Mechanism Section (2)
CDX-F5500/F5500X 4-4. CD MECHANISM SECTION (2) (MG-611MA-186//K) (including M901) M902 not supplied not supplied not supplied not supplied The components identified by Les composants identifiés par une mark 0 or dotted line with mark marque 0 sont critiques pour 0 are critical for safety. -
Page 37: Cd Mechanism Section (3)
CDX-F5500/F5500X 4-5. CD MECHANISM SECTION (3) (MG-611MA-186//K) M903 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 3-262-755-01 WASHER (1.1-2.5) 3-259-467-01 BRACKET (LEM) 3-259-024-01 WHEEL (RA), WORM 3-345-648-91 SCREW (M1.4), TOOTHED LOCK A-3337-633-A ARM ASSY, ROLLER A-3372-456-A WORM (LEB) ASSY... -
Page 38: Cd Mechanism Section (4)
CDX-F5500/F5500X 4-6. CD MECHANISM SECTION (4) (MG-611MA-186//K) Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 3-259-429-01 WHEEL (LE), WORM 3-899-829-01 WASHER (SLIT) 3-344-223-01 WASHER 3-259-032-01 GEAR (LE2) 3-259-470-01 GEAR (LE1) A-3372-453-A CHASSIS (M) BLOCK ASSY 3-253-755-01 LEVER (D) -
Page 39: Electrical Parts List
CDX-F5500/F5500X SECTION 5 DISPLAY ELECTRICAL PARTS LIST NOTE: • Due to standardization, replacements in • Items marked “*” are not stocked since The components identified by mark 0 or dotted line with mark the parts list may be different from the they are seldom required for routine service. - Page 40 CDX-F5500/F5500X DISPLAY MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R940 1-216-833-11 METAL CHIP 1/10W A-3283-508-A MAIN BOARD, COMPLETE (including R941 1-216-825-11 METAL CHIP 2.2K 1/10W SPEAKER BOARD) (F5500) R947 1-216-814-11 METAL CHIP 1/10W A-3283-509-A MAIN BOARD, COMPLETE (including...
- Page 41 CDX-F5500/F5500X MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C620 1-107-826-11 CERAMIC CHIP 0.1uF D817 8-719-109-97 DIODE RD6.8ES-B2 C701 1-124-584-00 ELECT 100uF D818 8-719-071-34 DIODE RB521S-30-TE61 C704 1-124-584-00 ELECT 100uF D821 8-719-109-97 DIODE RD6.8ES-B2 C705...
- Page 42 CDX-F5500/F5500X MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark Q402 6-550-752-01 TRANSISTOR DTC614TKT146 R608 1-216-809-11 METAL CHIP 1/10W Q403 6-550-752-01 TRANSISTOR DTC614TKT146 R615 1-216-821-11 METAL CHIP 1/10W Q404 6-550-752-01 TRANSISTOR DTC614TKT146 R705 1-216-809-11 METAL CHIP...
- Page 43 CDX-F5500/F5500X MAIN RELAY SENSOR SERVO Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R908 1-216-809-11 METAL CHIP 1/10W < SWITCH > R909 1-216-809-11 METAL CHIP 1/10W R910 1-216-809-11 METAL CHIP 1/10W S931 1-771-884-31 SWITCH, TACTILE (Z)
- Page 44 CDX-F5500/F5500X SERVO Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 1-107-826-11 CERAMIC CHIP 0.1uF 1-218-965-11 RES-CHIP 1/16W 1-125-837-11 CERAMIC CHIP 6.3V 1-208-635-11 RES-CHIP 1/16W 1-164-156-11 CERAMIC CHIP 0.1uF 1-218-971-11 RES-CHIP 1/16W 1-100-381-11 ELECT CHIP 10uF 1-218-971-11 RES-CHIP...
- Page 45 CDX-F5500/F5500X SERVO Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 1-218-941-81 RES-CHIP 1/16W MISCELLANEOUS 1-218-990-11 SHORT CHIP *************** 1-218-941-81 RES-CHIP 1/16W 1-218-941-81 RES-CHIP 1/16W 1-776-207-82 CORD (WITH CONNECTOR) (POWER) 1-218-977-11 RES-CHIP 100K 1/16W 0 153 8-820-207-02 OPTICAL PICK-UP (KSS1000E/K1RP)
- Page 46 CDX-F5500/F5500X REVISION HISTORY Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper on the revised page allows you to jump to the next revised page. Ver. Date Description of Revision 2003. 12...